Active Adaptive Vibration Absorbers And Fts Sibration -Books Download

Active adaptive Vibration Absorbers and fts sibration

2019 | 5 views | 0 downloads | 7 Pages | 526.19 KB

Active-adaptive Vibration Absorbers and fts sibration Attenuation Performance Chao Peng, Xinglong Gong CAp hey Laboratory of Mechanical Behavior and Design of Materials, aepartment of Modern MechaniI rniversity of pcience and Technology of ChinaI eefei 230027I China [email protected], [email protected]




Applied Mechanics and Materials Vol 312 263, The aim of this research is to improve working frequency band and vibration attenuation. performance of a vibration absorber Towards this end a mechanical AAVA was designed This. paper is split into four sections Following the introduction section the principle and the vibration. attenuation performance of the AAVA are analyzed in Section 2 Section 3 describes the prototype. of the AAVA and its dynamic property testing Section 4 presents the experiments of the vibration. attenuation effect of AAVA based on a clamped clamped beam The conclusions are summarized in. the final section,Analysis on AAVA,The Principle of the AAVA. To illustrate the working principle a single degree of freedom primary system with the AAVA is. described in Fig 1 The active element is placed between the absorber mass and the primary. system The m p c p k p are the mass damping and stiffness of the primary system respectively. The ma ca k a are the mass damping and stiffness of the AAVA respectively The x p xa are the. displacements of the primary system and the absorber mass respectively The f act is the active. force The f is the harmonic excitation force applied on the primary system. According to the references 7 different values of the parameters in Fig 1 represent different types. of vibration absorbers as shown in Table 1, Fig 1 Schematic view of the primary system Fig 2 Vibration attenuation effect of different. with a tuned vibration absorber types of vibration absorbers. Tab 1 Several typical vibration absorbers,TYPE ka ma f act. TVA constant 0,AVA constant ka ma 2 xa ca x a,AAVA 2 ca x a.
The is the frequency of excitation force The and are control efficient of AVA and. AAVA respectively According to Newton s law the equations of motion can be expressed as. ma xa ca xa x p k xa x p f act, m p x p c p x p ca x p xa k p x p k x p xa f f act. From Eq 1 the amplitude magnification coefficient of the primary system with different type. vibration absorbers attached can be obtained as follows. Z m Z k F Z m Fact,Zm Z p Zm Zk Z p Zk, 264 Applied Research and Engineering Solutions in Industry. Z k 2 jma a a ma a,Z p m p 2 jm p p p m p p, Where p k p mp p c p 2mp p a ka ma a ca 2ma a The p and p are. the natural frequency and damping ratio of the primary system respectively The a and a are. the natural frequency and damping ratio of vibration absorber respectively For the AAVA and. ATVA a tracks the frequency of excitation force For the TVA and AVA a is fixed at the. natural frequency of the primary system,Comparison of vibration reduction performance. The vibration attenuation effect of the vibration absorbers is defined as the ratio of the amplitude. magnification coefficient of the primary system with and without vibration absorber the dB. expression of the effect is,X p without, Where the X p with and X p without are the amplitude magnification coefficient of the primary.
system with and without vibration respectively According to the following parameters. ma mp 0 1 0 8 a 0 04 p 0 08 the effect of vibration absorption capacity can be. calculated, The comparison of four types of vibration absorbers with the same mass ratio and damping ratio. is shown in Fig 2 For the TVA the best vibration attenuation effect occurs at its natural frequency. When the excitation frequency is away from this frequency the effect decreases quickly The AVA. has better effect than TVA close by the natural frequency but the effect also becomes bad For. ATVA its vibration attenuation effect is equal to that of the TVA at its natural frequency and it has. better effect than TVA in the whole adjustable frequency band Nevertheless the superiority of the. ATVA compared with the TVA is not evident because of the large damping At the whole. frequency range the curve of AAVA s attenuation effect is below that of the other types of. vibration absorbers which indicates that the AAVA has the best vibration attenuation effect. The design and dynamic property of AAVA,The prototype of AAVA. According to previous analysis the AAVA has the best vibration attenuation effect compared. with other types of vibration absorbers It means that the AAVA is more suitable for engineering. application In this paper a mechanical AAVA is designed Fig 3 a shows a scheme of the. prototype and Fig 3 b shows a photograph of the prototype. Fig 3 The prototype of AAVA a Scheme b Photograph,Applied Mechanics and Materials Vol 312 265. The absorber mass of the prototype is a closed configuration which is composed of four. individual masses There are two horizontal guides mounted on the absorber mass Four horizontal. sliders can move in horizontal direction along the two horizontal guides This configuration can. make the best use of the space and reduce the size of the AAVA The leaf spring is chosen as the. spring pole because of the large bear load and lateral rigidity The stiffness element of the AAVA is. composed of four leaf springs The span between leaf springs can be changed which causes the. natural frequency of the AAVA changed If the span keeps at a fixed value the AAVA can be. regarded as ATV Four vertical guides mounted on the base are used to make the absorber mass to. move only in vibration direction The mass of the absorber mass is about 4 kilograms and the other. mass is about 1 kilogram, The active force is provided by a small voice coil motor The motor consists of a magnet and. motor coil The magnet is fixed to the absorber mass and the motor coil is fixed to the base When. a current flows through the motor coil an ampere force will be generated between the magnet and. the motor coil The amplitude and direction of the force can be controlled by the current If the. voice coil motor stop working the AAVA can be regarded as a translational ATVA. Dynamic characteristics of the prototype, Using the approaches have been proposed in references 8 9 the dynamic characteristics of the.
prototype can be obtained Fig 4 shows the frequency shift property curves and damping property. of the prototype, Fig 4 The experimental results of dynamic property. a The frequency shift property b The damping property. As described in this figure for either the ATVA or AAVA the natural frequency of prototype is. from 19 25Hz to 31 25Hz when the span changes from 26mm to 58mm The damping ratios are. obtained by using the half power bandwidth method It is shown that the average damping ratio of. ATVA are 0 04 and this value is 0 02 for AAVA As the AAVA introduces the active force it can. reduce the damping, Experimental evaluation of the vibration attenuation performance of the AAVA. To evaluate the vibration attenuation effect of the prototype of AAVA a clamped clamped beam. with a pullback weight attached was used as the primary system Fig 5 shows the schematic of the. experimental set up for evaluation of the vibration attenuation performance of the AAVA The first. mode of the beam is bending vibration and the natural frequency of mode is about 26Hz The. AAVA was mainly used to control this mode vibration so it was placed at the center of beam where. the vibration is the largest, As shown in Fig 5 an impedance head connects with the beam and the exciter and it measures. the force signal and the acceleration signal which is used as the input of the controller The ratio of. the force signal and the acceleration signal is the acceleration admittance of the beam With an. absorber attached the dynamic property of the beam changes and hence the admittance of the beam. changes Therefore the vibration attenuation effect of an absorber can be represented by comparing. the admittance of the beam with and without absorber. 266 Applied Research and Engineering Solutions in Industry. Fig 5 Experimental set up a Scheme b Photograph, 1 Prototype 2 Control box 3 Clamped clamped beam 4 Accelerometer. 5 Charger amplifier 6 Dynamic signal analyzer 7 Power amplifier 8 Computer 9 Exciter. Fig 6 Experimental results of the vibration attenuation effect. Fig 6 shows the experimental results of the vibration attenuation effect If the prototype is not. controlled and its resonant frequency is fixed at 26Hz the resonant frequency of the beam it can. be regarded as a TVA While the prototype is only controlled to trace the excitation force. frequency it can be looked as an ATVA As shown in Fig 6 for TVA the best vibration attenuation. effect occurs at its natural frequency The effect goes down when the excitation frequency is far. from this frequency At some frequencies the values of the effects are even larger than 0 indicating. that the vibration of the system is increased by the TVA For ATVA whose natural frequency is. tuned to trace the excitation frequency its vibration attenuation effect is better than that of the TVA. within the entire adjustable frequency band except at 26 Hz Nevertheless the superiority of the. ATVA compared with the TVA is not evident because of the large damping The AAVA has the. best vibration attenuation effect It can result in a reduction of vibration of the beam by up to. average 15 dB which is better than that achieved with the ATVA. Conclusions, In this work we developed a mechanical AAVA whose natural frequency can be tuned from 19 25.
Hz to 31 25 Hz by adjusting the span between the ends of two spring poles from 26cm to 58cm The. damping of the prototype is rather small and the average damping ratio was reduced to 0 02 from. 0 04 by the active force Experimental studies were conducted to evaluate the vibration attenuation. performance of the AAVA on a clamped clamped beam The results show that the AAVA has. better vibration attenuation performance than ATVA and TVA. Acknowledgments, Financial support from the National Natural Science Foundation of China Grant No 11125210. and the Funds of the Chinese Academy of Sciences for Key Topics in Innovation Engineering. Grant No KJCX2 EW L02 are gratefully acknowledged,Applied Mechanics and Materials Vol 312 267. References, 1 Jalili N Knowles D W IV Structural Vibration Control Using an Active Resonator. Absorber Modeling and Control Implementation Smart Materials and Structures 13 5 998. 2 Olgac N Hansen B H Design Considerations for Delayed Resonator Vibration Absorber. Journal of engineering mechanics 121 1 81 89 1995, 3 Franchek M A Ryan M W Bernhard R J Adaptive Passive Vibration Control Journal. of Sound and Vibration 189 5 565 585 1995, 4 Liu J and Liu K A Tunable Electromagnetic Vibration Absorber Characterization and.
Application Journal of Vibration and Acoustics 295 3 5 708 724 2006. 5 Rustighi E Brennan1 M J Mace B R A Shape Memory Alloy Adaptive Tuned Vibration. Absorber Design and Implementation Smart Materials and Structures 14 1 19 28 2005. 6 Kidner M R F Brennan M J Real time Control of Both Stiffness and Damping in an. Active Vibration Neutralizer Smart Materials and Structures 10 4 758 769 2001. 7 Sun H L Zhang P Q Gong X L Chen H B A Novel Kind of Active Resonator. Absorber and the Simulation on Its Active force Journal of Sound and Vibration 300 12 117. 8 Xu Z B Gong X L Liao G J Chen X M An Active damping compensated. Magnetorheological Elastomer Adaptive Tuned Vibration Absorber Journal of Intelligent. Material Systems and Structures 21 10 1039 1047 2010. 9 Gong X L Peng C Xuan S H Xu Y L Xu Z B A Pendulum like Tuned Vibration. Absorber and Its Application to Multi mode System Journal of Mechanical Science and. Technology 26 11 3411 3422 2012, Applied Research and Engineering Solutions in Industry. 10 4028 www scientific net AMM 312, Active Adaptive Vibration Absorbers and its Vibration Attenuation Performance.


Related Books

Emerging Contemporary Project Management Topics - Eric Tse

Emerging Contemporary Project Management Topics Eric Tse

The PROJECT PERFECT White Paper Collection 05/11/13 www.projectperfect.com.au Page 1 of 25 Emerging / Contemporary Project Management Topics 2012- 2013

MANDATORY LABELING REQUIREMENTS

MANDATORY LABELING REQUIREMENTS

Page 1 8/2/2018 Shell Egg Labeling guidelines for product bearing the USDA grademark. MANDATORY LABELING REQUIREMENTS A pplicable State regulations should be considered before submitting labels to AMS for approval.

Basic Concepts of Health Care Human Resource Management

Basic Concepts of Health Care Human Resource Management

iii Preface ix Acknowledgments xvii About the Author xix PART I Introduction 1 CHAPTER 1 What Is Human Resource Management? 3 Learning Objectives 3

Cosmetic and Reconstructive Procedures

Cosmetic and Reconstructive Procedures

Page 1 of 11 UHC MA Coverage Summary: Cosmetic and Reconstructive Procedures Proprietary Information of UnitedHealthcare. Copyright 2019 United HealthCare Services, Inc.

Site Name Course ID MBS # ISBN Adoption Status Pub Sub

Site Name Course ID MBS ISBN Adoption Status Pub Sub

denver cc ciss 242 programming ii 1415177 9780133769395 gaddis starting out w/c++,from cont..-w/access 8th 15 oe required pearson a-w denver cc ciss 391 information systems & sec 1364692 9781285448367 whitman principles of info.security 5th 16 oe required cengage l course tec

COP 2000 Introduction to Computer Programming I Syllabus ...

COP 2000 Introduction to Computer Programming I Syllabus

5 Regardless of what anyone else might tell you, your instructor will not file any type of withdrawal for you. There is a date within each semester after which a student is not permitted to withdraw from

Challenges in the Supply Chain for Advanced Materials

Challenges in the Supply Chain for Advanced Materials

www.linx-consulting.com Challenges in the Supply Chain for Advanced Materials Mark Thirsk . [email protected] +1 617 273 8837

MHPS Modular Hydro-Pneumatic Suspension System

MHPS Modular Hydro Pneumatic Suspension System

Subject to change MHPS40811en06/2016 Page 1 www.argo-hytos.com Modular Hydro-Pneumatic Suspension System Improving Suspension Performance with a Proper Setup: Quicker ...

PENGARUH KONSENTRASI TEPUNG MAIZENA TERHADAP SIFAT FISIK ...

PENGARUH KONSENTRASI TEPUNG MAIZENA TERHADAP SIFAT FISIK

i Rebecca Widyawati Kesumadewi (6103013115). Pengaruh Konsentrasi Tepung Maizena Terhadap Sifat Fisik Dan Organoleptik Es Krim Dengan Ovalet Sebagai Emulsifier.

BSNL VRS 2019 - Issue of Future Benefits

BSNL VRS 2019 Issue of Future Benefits

BSNL VRS 2019 - Issue of Future Benefits The BSNL VRS Scheme dt 4-11-2019 assures Terminal benefits as per the following para. 6.2 Terminal Benefits